Generac-power-systems 004917-4 Bedienungsanleitung

Installation andOwner’s ManualDEADLY EXHAUST FUMES. OUTDOOR INSTALLATION ONLY!!DANGERThis manual shouldremain with the unit.Liquid-cooled, Prepackaged

8 Generac®Power Systems, Inc.NOTE:Port 1 is for NG only and Port 2 is for LP vaporonly. No provision for dual fuel has been made.Serious injury or dam

Generac®Power Systems, Inc. 9Only qualified, competent installation contractors orelectricians thoroughly familiar with applicablecodes, standards and

10 Generac®Power Systems, Inc.• Allows the LOAD circuits to be connected to onlyone power supply at a time.• Prevents electrical backfeed between the

Generac®Power Systems, Inc. 11Failure to connect the generator neutral prop-erly will result in unbalanced line-to-neutralvoltages. Resulting high vol

12 Generac®Power Systems, Inc.• Spilled electrolyte is to be washed down with anacid-neutralizing agent. A common practice is touse a solution of one

Generac®Power Systems, Inc. 132.11.7 ELECTRICAL SYSTEMMake sure the generator is properly connected to anapproved earth ground and/or ground rod.Make

14 Generac®Power Systems, Inc.3.2.2 FAULT INDICATOR LEDThis LED goes ON when one or more of the followingengine faults occurs and when engine shuts do

Generac®Power Systems, Inc. 15Section 3 - OperationQUIETSOURCE™Liquid-cooled 30 kW Generators5. Reduce load to 3/4, 1/2, 1/4 and no load.Decrease the

16 Generac®Power Systems, Inc.4.1 MAINTENANCE PERFORMED BY AUTHORIZED SERVICE FACILITIES A. EVERY THREE MONTHS1. Check battery state of charge and con

Generac®Power Systems, Inc. 174.4.3 ENGINE COOLANTCheck coolant level in coolant recovery bottle. SeeSpecifications, Section 1.10.• Add recommended co

Generac®Power Systems, Inc.INTRODUCTIONThank you for purchasing this model of the standbygenerator set product line by Generac Power Systems. Every ef

18 Generac®Power Systems, Inc.7. Start engine and check for oil leaks.Figure 4.2 - Oil Filter4.5.11 CHANGING THE ENGINE AIR CLEANERTo replace the engi

Generac®Power Systems, Inc. 194.6.2 BATTERYAll lead-acid storage batteries discharge when not inuse. Refer to specific instructions and warnings thata

20 Generac®Power Systems, Inc.Section 4 — MaintenanceQUIETSOURCE™Liquid-cooled 30 kW Generators4.7 SCHEDULED MAINTENANCEFollowing is a recommended mai

Generac®Power Systems, Inc. 21Section 4 — MaintenanceQUIETSOURCE™Liquid-cooled 30 kW GeneratorsMaintenance Level 1 Level 2 Level 3 Level 4TasksRecom-

22 Generac®Power Systems, Inc.Section 4 — MaintenanceQUIETSOURCE™Liquid-cooled 30 kW GeneratorsMaintenance Level 1 Level 2 Level 3 Level 4TasksRecom-

Generac®Power Systems, Inc. 23Section 5 — TroubleshootingQUIETSOURCE™Liquid-cooled 30 kW GeneratorsTROUBLESHOOTING POINTSPROBLEM CAUSE CORRECTIONEngin

BRUSH ASSEMLY (GENERATOR)AUTOMATIC VOLTAGE REGULATORBULKHEAD CONNECTOR 1 (ENGINE)CIRCUIT BREAKER (EXCITATION)FUSE, BAT. POWER (15A AGC TYPE)CIRCUIT BR

Generac®Power Systems, Inc. 25LEGEND [CONT.]:J-2 -LOS -SM -JB -WLS -HCT -J-1 -IM -IC -ELEC. GOVERNOR ACTUATORGROUND (SENSING/LOW AMP)GROUND (POWER/

26 Generac®Power Systems, Inc.Section 6 - Electrical DataQUIETSOURCE™Liquid-cooled 30 kW GeneratorsElectrical Schematic — Engine — Drawing No. 0E6200-

Generac®Power Systems, Inc. 27Section 6 - Electrical DataQUIETSOURCE™Liquid-cooled 30 kW GeneratorsElectrical Schematic — Engine — Drawing No. 0E6200-

Table of ContentsQUIETSOURCE™Liquid-cooled 30 kW GeneratorsGenerac®Power Systems, Inc. 1INTRODUCTION...IF

30 Generac®Power Systems, Inc.

Generac®Power Systems, Inc. 31ITEM PART NO. QTY. DESCRIPTION1 0E8418 1 DUCT INTAKE MID AL2 0E8414 1 DUCT DISCHARGE RH AL3 0E8413 1 DUCT DISCHARGE LH A

32 Generac®Power Systems, Inc.Section 7 - Exploded Views and PartsQUIETSOURCE™Liquid-cooled 30 kW GeneratorsControl Panel — Drawing No. 0E7118-J

Generac®Power Systems, Inc. 33ITEM PART NO. QTY. DESCRIPTION1 0E7195 1 CONTROL BOX HSB2 0E7196 1 COVER FRONT PANEL HSB3 0E7197 1 COVER TOP PANEL HSB4

381185

ITEM PART NO. QTY. DESCRIPTION1 0E6202 1 ENGINE 3.0L FORD (RD) (MAKE)2 0E8824 2 STAMPING ENG FOOT 3.0L FORD3 0E8963 1 PULLEY CRANKSHAFT 3.0L FORDRD4 0

ENGINE5"A"12

ITEM PART NO. QTY. DESCRIPTION1 0E9947 1 RADIATOR R-IN,L-OUT 658X489X492 0E6340 1 VENTURI 3.0L FORD HSB3 0E8531 2 SIDE SUPPORT RADIATOR HSB4 0E6398 1

2 Generac®Power Systems, Inc.Study these SAFETY RULES carefully before installing,operating or servicing this equipment. Become familiarwith this Owne

38 Generac®Power Systems, Inc.28"B"3110164217591762932301129158363332914

Generac®Power Systems, Inc. 39ITEM PART NO. QTY. DESCRIPTION1 * --------- 1 WELDMENT MOUNTING BASE2 075580 1 FLANGE FUEL INLET3 0E7691 1 ASSY REGULATO

40 Generac®Power Systems, Inc.3

Generac®Power Systems, Inc. 41ITEM PART NO. QTY. DESCRIPTION1 0F1659A 1 ROTOR 390 15KW 1P DIRECT HSB (2.5L FORD)0F1657A 1 ROTOR 390 20KW 1P DIRECT HSB

ITEM PART NO. QTY. DESCRIPTION1 0F0738 1 MUFFLER 7"X9"-(2)2"IN/2.5"OUT2 0F6258 1 PIPE MUFFLER OUT3 044149 2 GASKET EXHAUST RING4 0

Generac®Power Systems, Inc. 43ITEM PART NO. QTY. DESCRIPTION1 0E5193 1 PLATE AIR CLEANER ADAPTER2 0E8200 1 TUBE AIR INTAKE 3.0L FORD3 0E8201 1 BRACKET

44 Generac®Power Systems, Inc.Section 8 — Installation DiagramQUIETSOURCE™Liquid-cooled 30 kW GeneratorsInstallation Diagram — Drawing No. 0E8696

Generac®Power Systems, Inc. 45Section 9 — NotesQUIETSOURCE™Liquid-cooled 30 kW Generators

Part No. 0F5546

Generac®Power Systems, Inc. 3• Inspect the generator regularly, and promptly repairor replace all worn, damaged or defective parts usingonly factory-a

4 Generac®Power Systems, Inc.1.1 GENERATORThis equipment is a liquid-cooled, engine-driven gen-erator set. The generator is designed to supply elec-tr

Generac®Power Systems, Inc. 51.6 GENERATOR FUEL SYSTEMThe unit has been factory tested and adjusted using anatural gas fuel system. If propane (LP) ga

6 Generac®Power Systems, Inc.Figure 1.6 - Low Coolant Level Sensor1.7.4 OVERSPEED SHUTDOWNThe engine control board receives AC frequency sig-nals from

1.10 SPECIFICATIONS1.10.1 GENERATOR SPECIFICATIONS1.10.2 ENGINE SPECIFICATIONSMake ..................